Inspections, Compliance, Enforcement, and Criminal Investigations
Louisiana Proteins DBA Riegel By-Products 17-May-06
Department of Health and Human Services
Public Health Service
New Orleans District
May 17, 2006
WARNING LETTER NO. 2006-NOL-06
Mr. William Shirley, Jr., Owner
Louisiana.DBA Riegel By-Products
2621 State Street
Dallas, Texas 75204
Dear Mr. Shirley:
On February 12, 17, 21, and 22, 2006, a U.S. Food & Drug Administration (FDA) investigator inspected your rendering plant, located at 509 Fortson Street, Shreveport, Louisiana. The inspection revealed significant deviations from the requirements set forth in Title 21, Code of Federal Regulations, Part 589.2000 [21 CFR 589.2000], Animal Proteins Prohibited in Ruminant Feed. This regulation is intended to prevent the establishment and amplification of Bovine Spongiform Encephalopathy (BSE). You failed to follow the requirements of this regulation; products being manufactured and distributed by your facility are misbranded within the meaning of Section 403(a)(1) [21 USC 343(a)(1)] of the Federal Food, Drug, and Cosmetic Act (the Act).
Our investigation found you failed to provide measures, including sufficient written procedures, to prevent commingling or cross-contamination and to maintain sufficient written procedures [21 CFR 589.2000(e)] because:
You failed to use clean-out procedures or other means adequate to prevent carryover of protein derived from mammalian tissues into animal protein or feeds which may be used for ruminants. For example, your facility uses the same equipment to process mammalian and poultry tissues. However, you use only hot water to clean the cookers between processing tissues from each species. You do not clean the auger, hammer mill, grinder, and spouts after processing mammalian tissues.
You failed to maintain written procedures specifying the clean-out procedures or other means to prevent carryover of protein derived from mammalian tissues into feeds which may be used for ruminants.
As a result . the poultry meal you manufacture may contain protein derived from mammalian tissues prohibited in ruminant feed. Pursuant to 21 CFR 589.2000(e)(1)(i), any products containing or may contain protein derived from mammalian tissues must be labeled, "Do not feed to cattle or other ruminants." Since you failed to label a product which may contain protein derived from mammalian tissues with the required cautionary statement. the poultry meal is misbranded under Section 403(a)(1) [21 USC 343(a)(1)] of the Act.
This letter is not intended as an all-inclusive list of violations at your facility. As a manufacturer of materials intended for animal feed use, you are responsible for ensuring your overall operation and the products you manufacture and distribute are in compliance with the law. You should take prompt action to correct these violations, and you should establish a system whereby violations do not recur. Failure to promptly correct these violations may result in regulatory action, such as seizure and/or injunction, without further notice.
You should notify this office in writing within 15 working days of receiving this letter, outlining the specific steps you have taken to bring your firm into compliance with the law. Your response should include an explanation of each step taken to correct the violations and prevent their recurrence. If corrective action cannot be completed within 15 working days, state the reason for the delay and the date by which the corrections will be completed. Include copies of any available documentation demonstrating corrections have been made.
Your reply should be directed to Mark W. Rivero, Compliance Officer, U.S. Food and Drug Administration, 2424 Edenborn Avenue, Suite 410, Metairie, Louisiana 70001. If you have questions regarding any issue in this letter, please contact Mr. Rivero at (504) 219-8818, extension 103.
Carol S. Sanchez
Acting District Director
New Orleans District